Archive for the ‘XS-D’ Tag

XS650: Oil Filters   1 comment

Had my hands in a couple of motors last week. An early XS1 that, judging from the bearing seats, has had as hard a life as Keith Richards face. An XS-D that looks pretty clean inside. Both had what look like original filters.

p2010221

Top: XS-D .. Bottom: XS1 – both showed damage from over-tightening the screws.

Neither gasket had been pre-treated before installation. An SF hammer was required. The gaskets did separate. In half.

p2010216

Early filter left with full metal jacket. Right: pleated mesh with magnet, right-hand end slightly crushed. Mesh on both sides intact.

p2010217

Rear: Early filter has no magnets. Mesh is only spot-welded. Later filter has magnets both sides. Mesh is fully cemented. Much more surface area. Mesh is finer.

Early oil flow problems? Filtration issues? Strange the prone corner was never properly reinforced.

p2010219

Left ends intact.

p2010220

Fronts. XS1 filter, mesh has started to separate at the spot-welds.

Although I’ve seen much worse both these motors could have benefited from a few more oil changes.

Was pleasantly surprised to see the original XS1 filter here. And that it had survived so much punishment for so long before giving out.

Both engines have obviously been warmed up slowly-the ends are still intact. The mesh separation on the early filter probably derives from crankshaft rotation – from the look of the bearing seats this motor has sung – full throat – louder than Sleazy Joe.
(143.2dB in Hassleholm, Sweden, 2008)

The XS-D filter could make a good emergency reserve. After fitting an end protector. And rechecking each oil change.

Take care of your engines and they will take care of you. These are very much ladies.

Advertisements

Posted February 1, 2016 by xscafe in Motor - Oil, Uncategorized

Tagged with , , ,

XS650: 77 XS-D Wiring Diagram   Leave a comment

XS-D Wiring Diagrams. Thought about transferring the key onto the diagram but couldn’t get it to work.

Click through twice on them to enlarge.

Europe:

77 XS-D Wiring Diagram … Europe

77 XS-D Wiring Diagram Key … Europe

Canada:

77 XS-D Wiring Diagram … Canada

77 XS-D Wiring Diagram Key … Canada

Other: (not European or Canadian Markets)

77 XS-D Wiring Diagram … Other

77 XS-D Wiring Diagram Key … Other

Posted February 26, 2012 by xscafe in Elec - diagram

Tagged with , , , , , , , , , , ,